生物质混流式固定床气化炉运行特性分析
收稿日期: 2015-05-18
修回日期: 2015-05-27
网络出版日期: 2015-06-30
基金资助
国家自然科学基金项目（51176194）；
广东省战略新兴产业项目（2012A032300019）
Gasification Performance of Biomass in a Coupled Drafting Fixed Bed Gasifier
Received date: 2015-05-18
Revised date: 2015-05-27
Online published: 2015-06-30
以桉木为原料，对1.5 t/h生物质混流式固定床气化炉运行特性进行了测试分析与评价，与文献报导报道的相关炉型包括上吸式、下吸式、两段式等炉型运行结果进行了比较。实验以气化炉空气通入量作为主要控制变量，对有或无水蒸气条件下的气化炉温度及压力分布、燃气组成、焦油与飞灰含量、气体产率等参数进行了较长周期的测试，结果表明：气化炉运行效果符合设计要求，各项指标相当于或优于传统的下吸式气化炉；气化炉运行温度与压力比较稳定；以冷燃气计算的燃气热值一般约为4 900 ~ 5 500 kJ/Nm3；气化效率约为70% ~ 78%；燃气焦油含量约600 ~ 3 500 mg/Nm3，运行负荷在50%以上时，焦油含量一般低于1 500 mg/Nm3。研究结果有望为混流式气化炉的改进和操作提供优化建议，同时可为其他气化工艺设计提供参考依据。
胡夏雨 , 袁洪友 , 谢建军 , 周肇秋 , 潘贤齐 , 阴秀丽 , 吴创之 . 生物质混流式固定床气化炉运行特性分析[J]. 新能源进展, 2015 , 3(3) : 163 -168 . DOI: 10.3969/j.issn.2095-560X.2015.03.001
This paper evaluated the gasification performance of a 1.5 t/h coupled drafting fixed bed gasifier using eucalypt, and compared the operating parameters to other fixed bed gasifiers from literatures including updraft, downdraft and two-stage. The air with or without steam input amount was selected as a major controlling variable, temperature and pressure distribution, syngas composition, tar and fly ash content, gas yield were tested in a long period. The results show that the operating performance of the coupled drafting gasifier meets the design requirements. The operating temperature and pressure are relatively stable. The syngas calorific value is approximately 4 900 ~ 5 500 kJ/Nm3. In most of running conditions, the cold gas efficiency of about 70% ~ 78% could be obtained. The syngas tar content is mainly in the range of 600 ~ 3 500 mg/Nm3 and generally lower than 1 500 mg/Nm3 when running at capacities of higher than 50%. The parameters considered are all equal to or better than conventional downdraft fixed bed gasifier. The results are expected to improve the design and operation of the coupled drafting gasifier, and also to provide a reference for other gasification process.
Key words： biomass; coupled drafting fixed bed; gasification; cold gas efficiency; tar
[1] Asadullah M. Barriers of commercial power generation using biomass gasification gas: A review[J]. Renew Sust Energ Rev, 2014, 29(1): 201-215.
[2] Ruiz J A, Juarez M C, Morales M P, et al. Biomass gasification for electricity generation: Review of current technology barriers[J]. Renew Sust Energ Rev, 2013, 18(2): 174-183.
[3] Senapati P K, Behera S. Experimental investigation on an entrained flow type biomass gasification system using coconut coir dust as powdery biomass feedstock[J]. Bioresour Technol, 2012, 117: 99-106.
[4] Asadullah M. Biomass gasification gas cleaning for downstream applications: A comparative critical review[J]. Renew Sust Energ Rev, 2014, 40: 118-132.
[5] Shen Y F, Yoshikawa K. Recent progresses in catalytic tar elimination during biomass gasification or pyrolysis-A review[J]. Renew Sust Energ Rev, 2013, 21: 371-392.
[6] Shen Y F. Chars as carbonaceous adsorbents/catalysts for tar elimination during biomass pyrolysis or gasification[J]. Renew Sust Energ Rev, 2015, 43: 281-295.
[7] Ahrenfeldt J, Egsgaard H, Stelte W, et al. The influence of partial oxidation mechanisms on tar destruction in TwoStage biomass gasification[J]. Fuel, 2013, 112: 662-680.
[8] Materazzi M, Lettieri P, Mazzei L, et al. Tar evolution in a two stage fluid bed-plasma gasification process for waste valorization[J]. Fuel Processing Technology, 2014, 128: 146-157.
[9] 苏德仁, 黄艳琴, 周肇秋, 等. 两段式固定床富氧−水蒸气气化实验研究[J]. 燃料化学学报, 2011, 39(8): 595-599.
[10] 闫桂焕, 孙荣峰, 许敏, 等. 生物质固定床两步法气化技术[J]. 农业机械学报, 2010, 41(4): 101-104.
[11] 陈亮, 苏毅, 陈祎, 等. 两段式秸秆气化炉中当量比对气化特性的影响[J]. 中国电机工程学报, 2009, 29(29): 102-107.
[12] 吴创之, 潘贤齐, 周肇秋, 等. 一种生物质混流式气化装置[P]. 中国: ZL201120164215.9, 2011.
[13] Phuphuakrat T, Namioka T, Yoshikawa K. Tar removal from biomass pyrolysis gas in two-step function of decomposition and adsorption[J]. Appl Energy, 2010, 87(7): 2203-2211.
[14] Good J, Ventress L, Knoef H, et al. Sampling and analysis of tar and particles in biomass producer gases (CEN BT/TF 143)[R]. http://www.eeci.net/2005.
[15] 葛建, 齐国利, 董芃. 生物质焦油的特性分析及提质研究[J]. 哈尔滨商业大学学报(自然科学版), 2012, 28(1): 27-30.
[16] 张世红, 李相鹏, 何广昌, 等. 顶部点火上吸式固定床中农业废弃物气化特性分析[J]. 农业工程学报, 2013, 29(10): 196-202.
[17] 魏敦崧, 李芳芹, 李连民. 生物质固定床气化试验研究[J]. 同济大学学报(自然科学版), 2006, 34(2): 254-259.
[18] 方原欢, 陈砺, 王红林. 南方农林废弃物的固定床气化特性研究[J]. 太阳能学报, 2009, 30(8): 1118-1123.
[19] Perez J F, Melgar A, Benjumea P N. Effect of operating and design parameters on the gasification/combustion process of waste biomass in fixed bed downdraft reactors: An experimental study[J]. Fuel, 2012, 96(1): 487-496.
[20] Brandt P, Larsen E, Henriksen U. High tar reduction in a two-stage gasifier[J]. Energy Fuels, 2000, 14(4): 816-819.
[21] 赖艳华, 吕明新, 马春元, 等. 两段气化对降低生物质气化过程焦油生成量的影响[J]. 燃烧科学与技术, 2002, 8(5): 478-481.
/
| 〈 |
|
〉 |
