对微平板燃烧器内4种烷类燃料（C1 ~ C4）进行铂催化燃烧实验,获得其点火过程和静态火焰的特征,并进行对比分析。当量比相同时,点火过程火焰传播速度大小顺序为甲烷 > 乙烷 > 丁烷 > 丙烷。随着当量比增大,火焰传播速度加快,稳态火焰根部位置向气流上游移动。观察可见光、430 nm（OH*光谱）、516 nm（C2*光谱）成像火焰发现,当量比越大,火焰亮度越大,OH*和C2*浓度越高。当量比相同时,乙烷的OH*、CH*和C2*浓度最高,而甲烷和丙烷的则较低。
Combustion of four alkane fuels (C1 ~ C4) in a micro-plat combustor catalyzed by Platinum were performed to studied their ignition process and static flame. When with a same equivalent ratio, the order of the flame propagation velocity was methane > ethane > butane > propane. The propagation velocity increase with the equivalent ratio, and the steady-state flame root position of the fuels move upstream of the airflow. Flame images of the visible light, 430 nm (OH* spectrum), 516 nm (C2* spectrum) were observed, and it was found that, the larger the equivalent ratio was the greater the flame intensity was in the same fuel, and the concentration of OH* and C2* were higher. Under the same equivalent ratio condition, the OH*, CH*, and C2* concentrations of ethane were the highest, while the concentrations of methane and propane were lower.
[1] MARUTA K.Micro and mesoscale combustion[J]. Proceedings of the combustion institute, 2011, 33(1): 125-150. DOI: 10.1016/j.proci.2010.09.005.
[2] JU Y G, MARUTA K.Microscale combustion: Technology development and fundamental research[J]. Progress in energy and combustion science, 2011, 37(6): 669-715. DOI: 10.1016/j.pecs.2011.03.001.
[3] 陈俊杰, 王谦. 微尺度催化燃烧的研究进展[J]. 应用化工, 2008, 37(11): 1376-1380. DOI: 10.3969/j.issn.1671- 3206.2008.11.034.
[4] 钟北京, 焦健. 微通道内甲烷空气预混气的熄火极限[J]. 清华大学学报(自然科学版), 2007, 47(11): 2044-2047. DOI: 10.3321/j.issn:1000-0054.2007.11.028.
[5] 冯耀勋, 王勇, 蒋利桥, 等. 多孔介质表面火焰最小稳燃空间实验研究[J]. 中国电机工程学报, 2011, 31(20): 46-51. DOI: 10.13334/j.0258-8013.pcsee.2011.20.014.
[6] 周俊虎, 汪洋, 杨卫娟, 等. 燃料气体预热温度对微燃烧器性能影响的分析[J]. 农业机械学报, 2010, 41(8): 90-93, 106. DOI: 10.3969/j.issn.1000-1298.2010.08.019.
[7] 杨卫娟, 周俊虎, 汪洋, 等. 微尺度燃烧中的温度及热回流分布[J]. 中国电机工程学报, 2010, 30(20): 28-32. DOI: 10.13334/j.0258-8013.pcsee.2010.20.012.
[8] 张永生, 周俊虎, 杨卫娟, 等. 微燃烧稳定性分析和微细管道燃烧实验研究[J]. 浙江大学学报(工学版), 2006, 40(7): 1178-1182. DOI: 10.3785/j.issn.1008-973X.2006. 07.017.
[9] 潘剑锋, 刘启胜, 卢青波, 等. 催化微燃烧室内氢气和氧气预混合燃烧特性[J]. 农业机械学报, 2016, 47(2): 357-363. DOI: 10.6041/j.issn.1000-1298.2016.02.047.
[10] 焦健, 钟北京. 甲烷微通道内催化燃烧有关转化率的讨论[J]. 工程热物理学报, 2007, 28(2): 357-359. DOI: 10.3321/j.issn:0253-231X.2007.02.055.
[11] 潘剑锋, 范宝伟, 吴庆瑞, 等. 微尺度下氢氧预混合气催化燃烧的研究[J]. 机械工程学报, 2011, 47(24): 111-116. DOI: 10.3901/JME.2011.24.111.
[12] FAN A W, WAN J L, LIU Y, et al.Effect of bluff body shape on the blow-off limit of hydrogen/air flame in a planar micro-combustor[J]. Applied thermal engineering, 2014, 62(1): 13-19. DOI: 10.1016/j.applthermaleng.2013. 09.010.
[13] TANG A K, XU Y M, PAN J F, et al.Combustion characteristics and performance evaluation of premixed methane/air with hydrogen addition in a micro-planar combustor[J]. Chemical engineering science, 2015, 131: 235-242. DOI: 10.1016/j.ces.2015.03.030.
[14] SAIKI Y, SUZUKI Y.Effect of wall surface reaction on a methane-air premixed flame in narrow channels with different wall materials[J]. Proceedings of the combustion institute, 2013, 34(2): 3395-3402. DOI: 10.1016/j.proci. 2012.06.095.
[15] 潘剑锋, 万彦辉, 李德桃, 等. 甲烷和氢气在亚毫米微燃烧室内燃烧的试验对比[J]. 热科学与技术, 2010, 9(4): 333-338. DOI: 10.3969/j.issn.1671-8097.2010.04.009.
[16] CHOI W, KWON S, SHIN H D.Combustion characteristics of hydrogen-air premixed gas in a sub-millimeter scale catalytic combustor[J]. International journal of hydrogen energy, 2008, 33(9): 2400-2408. DOI: 10.1016/j.ijhydene.2008.02.070.
[17] TANG A K, XU Y M, SHAN C X, et al.A comparative study on combustion characteristics of methane, propane and hydrogen fuels in a micro-combustor[J]. International journal of hydrogen energy, 2015, 40(9): 16587-16596. DOI: 10.1016/j.ijhydene.2015.09.101.
[18] MIHAI O, FATHALI A, AUVRAY X, et al. DME, propane and CO: the oxidation, steam reforming and WGS over Pt/Al2O3. The effect of aging and presence of water[J]. Applied catalysis B: environmental, 2014, 160-161: 480-491. DOI: 10.1016/j.apcatb.2014.05.048.
[19] VINCENT R S, LINDSTEDT R P, MALIK N A, et al.The dynamics of partial oxidation of ethane over platinum[J]. Proceedings of the combustion institute, 2011, 33(2): 1809-1817. DOI: 10.1016/j.proci.2010.05.034.
[20] 熊鹏飞, 钟北京, 杨帆, 等. C1-C4在Pt催化剂上的多相反应机理[J]. 物理化学学报, 2011, 27(9): 2200-2208.
[21] 胡二江, 黄佐华, 姜雪, 等. C1-C4烷烃预混层流燃烧与着火特性研究[J]. 工程热物理学报, 2013, 34(3): 558-562.
[22] 宋旭东, 郭庆华, 张婷, 等. 甲烷同轴射流扩散火焰中自由基的辐射特性[J]. 中国电机工程学报, 2013, 33(35): 50-57. DOI: 10.13334/j.0258-8013.pcsee.2013.35.010.
[23] RENLUND A M, SHOKOOHI F, REISLER H, et al.Reaction of ethynyl radical with oxygen. Chemiluminescent products[J]. The journal of physical chemistry, 1982, 86(21): 4165-4170. DOI: 10.1021/j100218a015.
[24] 王亚薇, 钟北京. 正丁烷催化燃烧数值模拟及影响因素分析[J]. 新能源进展, 2017, 5(1): 1-7. DOI: 10.3969/j. issn.2095-560X.2017.01.001.
